Elite G40
Pump
Only
- 764-102
Complete-
764-100
Hose Rack
r
/GasTank
Figure 2
Throttle
~
/Air
Filter
. . Engine Muffler
.Clutch
Choke .
Fuel
Shut-off
Pull Start
Pressure
Adjustment Knob
Paint
Fi·
...
-·.___,
--GearBox
Add
P.S.L.
Here
Pail Hook
Fluid Section
Oil
Alert Waming Ught
Figure 3
Figure 1
General Repair &
Service
Notes:
WARNING:
Before
proceeding,
follow
the
Pressure
Relief Procedure outlined
on
page 5. Additionally,
follow
all
other
warnings
to
reduce
the
risk
of
an
injection injury, injury
from
moving
parts
or
electric
shock.
Always unplug
the
sprayer before servicing!
The following tools are needed when repairing this
sprayer:
Phillips Screwdriver 3/8" Allen Wrench
Needle Nose Pliers 5/16" Allen Wrench
Adjustable Wrench 1/4" Allen Wrench
Rubber
Mallet 3/16" Allen Wrench
Flatblade Screwdriver 1/8" Allen Wrench
1/2"
Open End Wrench
1. Before repairing any part
of
the sprayer, read the
instructions
carefully, including all warnings.
2. When disconnecting wires, use
needle nose pliers to ,
separate mating connectors. ·
3
NOTE:
Repacking Kit 762-175
is
available.
All
parts included in the
Kit
are marked
with
a
11
~
11
in parts list chart on page
24.
For best
results use all parts and tools supplied
in
the Repacking Kit.
CAUTION: Never
pull
on
a
wire
to
disconnect
it.
Pulling
on
a wire could loosen the connector from the
wire.
·
3.
Test your repair before regular operation
of
the
sprayer to be sure that the
problem is corrected. If the
sprayer does not operate
properly, review the repair
procedure to determine if everything was done
correctly. Refer to the Troubleshooting Charts to help
identify other possible problems.
4. Make certain that the service area is well ventilated
in
case solvents are used during cleaning. Always
wear protective eyewear while servicing. Additional
protective equipment may be required depending on
the type
of
cleaning solvent. Always contact the
supplier
of
solvents for recommendations.
5.
If you have any further questions concerning your
TITAN Airless Sprayer, call TITAN Customer Service
Department at 1-800-526-5362
..
