Electrical
System
Reelmaster 6500-D/6700-D
Page 5 - 1
Electrical System (Rev. C)
Chapter 5
Electrical System
Table of Contents
ELECTRICAL SCHEMATICS,
ELECTRICAL HARNESS, and
CONNECTOR DRAWINGS See Chapter 8.......
SPECIAL TOOLS 2.............................
TROUBLESHOOTING 4.........................
Understanding the Controllers 4.................
Understanding the Diagnostic Lamps 5...........
Using the ACEt Diagnostic Display 6............
TurfDefendertLeak Detector 8.................
Leak Detector Troubleshooting Guide 12.........
Starting Problems 13..........................
General Run and Transport Problems 14.........
Cutting Unit Operation Problems 15..............
ELECTRICAL SYSTEM QUICK CHECKS 17.......
Battery Test (Open Circuit Test) 17...............
Charging System Test 17.......................
Voltage Drop Testing 17........................
Glow Plug System Test 18......................
Starting System Test 18........................
COMPONENT TESTING 19......................
Ignition Switch 19.............................
Glow and Start R elays 20.......................
Fuses 21.....................................
Hydraulic Valve Solenoids 22...................
High Temperature Warning and Shutdown
Switch 23....................................
Warning Light Cluster 24.......................
Run (ETR) Solenoid (Solenoid With 3 Wire
Connector) 25................................
Run (ETR) Solenoid (Solenoid With 2 Wire
Connector) 26................................
Fuel Gauge Sender 27.........................
Fuel Gauge 28................................
Temperature Sender 29........................
Temperature Gauge 30.........................
Hourmeter 31.................................
Electronic Controller(s) 31......................
Parking Brake Switch 31.......................
Engine Low Oil Pressure Switch 32..............
Speedometer Sensor 32.......................
Speedometer 33..............................
Reel Enable/Disable Switches 33................
Reel Backlap Switches 34......................
Traction Neutral Switch 34......................
Seat Sensor 35...............................
Joystick Raise and Lower/Mow Switches 35......
Cutting Unit Down Sensors 36..................
Cutting Unit #6 and #7 Reel On/Off Solenoids 36..
SERVICE and REPAIRS 37......................
Battery Storage 37............................
Battery Care 37...............................
Battery Service 38.............................
Speedometer Sensor Replacement 41...........
Installing Optional Lighting 42...................
